Engine stalls or loses power while driving

Risk: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.

Risk: The improper heat treatment can result in the halfshaft breaking, preventing the engine from moving the vehicle, and can allow a possible roll away situation if the parking brake is not engaged. This can increase the risk of a crash.
Remedy: Honda will notify owners, and dealers will inspect the halfshaft's serial number, replacing it as necessary and aligning the front wheels, free of charge. The recall began December 8, 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is K0E.

This investigation was prompted by Preliminary Evaluation (PE) 11-017, and was based on reports from consumers alleging that both low beam headlights stopped illuminating simultaneously.Some complainants also reported that the combination switch (switch) that controls the headlights and turn signals, and/or its electrical wiring harness connector were damaged by overheating.ODI's PE information request letter asked Honda for certain data on model years (MY) 2002-2006 CR-V, 2003-2008 Pilot, 2003-2008 Element, 2001-2005 Civic, and 2000-2001 S 2000 vehicles.Analysis of complaint and Honda data show that a complete low beam headlight circuit failure occurs in models with 2-bulb headlight systems (i.e., a single bulb on each side for high and low beam).Models with 2-bulb systems include MY 2002-2004 CR-V, 2003-2005 Pilot, 2001-2003 Civic, and 2003-2008 Element.Models with 4-bulb headlight systems (i.e., two bulbs on each side, one for high and one for low beam) have different electrical circuits for the headlights and do not experience the same failure mechanism as the 2-bulb system.MY 2000-2001 S 2000 models with 2-bulb high intensity discharge headlights also have different electrical circuits for the headlights and do not experience the same failure mechanism.Honda introduced the 4-bulb headlight system in CR-V in MY 2005, in Pilot in MY 2006, and in Civic in MY 2004.On March 29, 2012 Honda submitted a defect information report (DIR) to recall 554,428 vehicles, including MY 200

On August 4, 2010, American Honda Motor Co. (Honda) submitted a Defect Information Report (DIR) to NHTSA regarding a ignition interlock defect in approximately 384,220 model year (MY) 2003 Honda Accord and Civic and MY 2003 and 2004 Honda Element vehicles with automatic transmissions (Recall 10V-364).In a September 22, 2010 supplemental DIR, Honda expanded the scope of the recall population based on manufacturing and complaint data.The total population for the complete recall is approximately 551,498 vehicles.The information listed in this closing report refers only to the subject vehicles, MY 2003 Accords with automatic transmissions.According to Honda's DIR, Under certain conditions the interlock lever of the ignition switch may unexpectedly deform, which can allow the interlock function of a vehicle with an automatic transmission to be defeated if the driver does not follow the typical shut-down procedure of shifting the gear selector to the Park position before rotating the ignition key to the off position. Removal of the ignition key when the gear selector of a vehicle with an automatic transmission has not been shifted to the Park position can allow the vehicle to roll away, increasing the risk of a crash.Honda's dealers will be instructed to inspect the ignition interlock switch and, if necessary, replace the original interlock pin and lever within the ignition switch and replace them with new, redesigned parts.This investigation is closed.

IN MID-APRIL 2007, HONDA INFORMED ODI OF A CNG TANK EXPLOSION INCIDENT THAT OCCURRED ON A SUBJECT VEHICLE.THE INCIDENT OCCURRED AFTER AN ARSONIST BROKE INTO A LOT WHERE MULTIPLE VEHICLES, INCLUDING A SUBJECT VEHICLE, WERE STORED AND SET THE VEHICLES ON FIRE.DURING THE FIRE, THE PRESSURE RELIEF DEVICE (PRD) ON THE SUBJECT VEHICLE ALLEGEDLY FAILED TO ACTIVATE AND THE COMPRESSED NATURAL GAS (CNG) TANK EXPLODED.THE EXPLOSION OCCURRED WITH FIRE FIGHTERS AT THE SCENE.NO INJURIES WERE REPORTED. CNG TANKS ARE SUBJECT TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 304 - COMPRESSED NATURAL GAS FUEL CONTAINER INTEGRITY.THIS STANDARD REQUIRES THAT EACH CNG FUEL CONTAINER SHALL COMPLETELY VENT ITS CONTENTS THROUGH A PRD OR SHALL NOT BURST WHILE RETAINING ITS ENTIRE CONTENTS WHEN TESTED ACCORDING TO THE STANDARD'S BONFIRE TEST PROCEDURE. A CNG TANK EXPLOSION RAPIDLY RELEASES A LARGE QUANTITY OF ENERGY AND COULD RESULT IN CATASTROPHIC INJURIES, DEATHS, AND PROPERTY DAMAGE. AS A RESULT OF HONDA'S TESTING AND REVIEW OF THE INVOLVED VEHICLE, HONDA HAS DEVELOPED AN INSULATOR TO INSULATE THE CNG FUEL TANK FROM A LOCALLY DIRECTED FLAME PROJECTING FROM THE INTERIOR OF THE VEHICLE.INSULATORS WILL BE INSTALLED BEHIND THE BACK SEAT ON SUBJECT VEHICLES TO PREVENT FUTURE FAILURES OF THIS TYPE.HONDA'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.

THE PETITION ALLEGES THAT IGNITION DISTRIBUTOR FAILURE COULD CAUSE A VEHICLE FIRE OR A TRAFFIC ACCIDENT

There is no summary currently available