Engine stalls or loses power while driving

On December 2, 2022, the Office of Defects Investigation (ODI) opened PE22-013 to investigate allegations of loss of motive power accompanied by high coolant temperature messages on the dashboard of Model Year 2019-2020 Jeep Compass vehicles. At the time this investigation was opened, ODI was aware of fifteen Vehicle Owner Questionnaires (VOQs) for Model Year (MY) 2019-2020 Jeep Compass vehicles alleging a loss of motive power (LOMP) while driving. The LOMP events were often accompanied by a high coolant temperature or coolant temperature too high message appearing on the dashboard of the vehicle. In most incidents, the high coolant temperature or coolant temperature too high dashboard messages spontaneously self-corrected or were corrected after the vehicle was stopped and restarted. One complainant alleged no immediate restart, and the vehicle was towed. A Preliminary Evaluation (PE) was opened to assess the frequency and potential safety consequences of these engine shut down events. On January 19th, 2023, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2019-2020 Jeep Compass vehicles. FCA provided its full response on March 2nd, 2023. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of available information, ODI has identified 173 subject vehicles that likely experienced a shutdown event associa

On December 13, 2016, the National Highway Traffic Safety Administration (NHTSA) received recall 16V-907 from Fiat Chrysler Automobiles (FCA) that identified a safety defect involving crankshaft or camshaft sensor failures on certain 2016 Model Year Dodge Journey, Jeep Compass, and Jeep Patriot vehicles. The failure of the crankshaft or camshaft sensor may lead to a loss of motive power (LOMP) in the recalled vehicles. Following the receipt of recall 16V-907, the Office of Defects Investigation (ODI) received 127 vehicle owner’s questionnaires (VOQ), in which consumers allege experiencing crankshaft or camshaft failures on similar vehicles not included in the recall. On July 22, 2022, this Recall Query was opened to further assess the scope, frequency, and safety consequences of the alleged defect described in the recall. During this investigation, ODI sent two information request (IR) letters to FCA. The first letter was sent on August 15, 2022, and the second on July 12, 2024. Responses to these IR letters, that included manufacturer claim data related to the alleged defect, were received on September 26, 2022, and September 6, 2024, respectively. Analysis of ODI and FCA claim data identified two failure modes relating to intermittent crankshaft and camshaft sensor loss of signal. The first failure mode involves a faulty crankshaft or camshaft electrical connector, as identified in recall 16V-907. The second failure mode involves a faulty crankshaft and/or camsh

NHTSA opened AQ17-004 to determine whether Northwest Chrysler Jeep Dodge of Houston, Texas (Northwest) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C. Chapter 301 (Safety Act) and its implementing regulations. The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. 30120(i)). NHTSA issued information request letters (IRs) to Northwest and Fiat Chrysler Automobiles US LLC (FCA) in August 2017, and again in October 2017 and December 2017. NHTSA's investigation indicated that Northwest sold and delivered at least 310 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers. On August 19, 2020, NHTSA entered into a Settlement Agreement with Northwest and its parent company, Ken Garff Automotive LLC, to resolve the Audit Query. In the agreement, Northwest agreed to pay a $100,000 civil penalty and Ken Garff agreed to certain training and auditing requirements. The training relates to company policy, procedures, and compliance to prohibit sales of motor vehicles with open recalls and the integration of FCA's recall notifications into the dealership's inventory system.This Audit Query is closed.