Third generation
2015 Ford F-350 Super Duty
The most reported problem on the 2015 Ford F-350 Super Duty is suspension, with 65 complaints, usually around 82,000 miles.
- 207owner complaints
- 4recalls
- 3involved a crash
- 61,000median miles at failure
Newest report Sep 15, 2026 · checked Oct 2, 2026
What is your F-350 Super Duty doing?
Each one opens a sheet built from the owner reports of that problem on the 2015 model year.
Is the 2015 Ford F-350 Super Duty reliable?
The 2015 Ford F-350 Super Duty has 207 owner complaints on file with NHTSA, below the median of 299 for 2015 pickups on this site. Of the 11 F-350 Super Duty model years since 2015, it has the 4th most complaints. Complaint counts rise with sales as well as faults, so read what owners report below before deciding.
At a glance
- Next to other model years
- Complaints filed before 2015 aren't in the files this site reads, so the 2015 count runs short and isn't compared with the model years next to it.
- Top problem
- Two problems run close. Suspension has 65 complaints and death wobble has 63, out of 207 in all. A quarter of the 33 owners who gave a mileage for suspension saw it by about 50,000 miles, and half by about 82,000.
- Crash, fire and injury reports
- 11 of the 207 complaints (5%) report a crash, a fire or an injury, about the 6% typical of vehicles on this site. Counted separately (one report can carry more than one), 3 reports mention a crash, 7 mention a fire and 1 person was hurt.
- Recalls behind the top problems
- Death wobble has a recall on the same system (20E-090). Suspension has none. A recall on the same system doesn't always cover the failure owners describe, so compare its summary with the complaints.
- When owners filed
- Filings peaked in 2021 at 37 (full calendar years only). In 2025 there were 22. So far in 2026, 9 more have come in. Filings on record start in 2015.
When each problem shows up
Each bar covers the middle half of the mileages owners reported for that problem. A quarter saw it earlier, a quarter later. The tick is the median. Most reported: suspension noise, struts or alignment, 65 complaints.
middle half of reports, median tick. The heavier grey bars have 75 or more reports.
Behind you
Around your mileage
Ahead of you
How this compares
207 complaints is 1.3 times fewer than the median 2015 model on this site and 1.4 times fewer than the median 2015 pickup. Among the 7 F-350 Super Duty model years here it ranks 4th for complaints. Counts follow sales volume as much as reliability, so a truck that sells 700,000 a year draws more reports than a sedan that sells 200,000.
Service bulletins for the 2015 Ford F-350 Super Duty
Ford filed 128 bulletins and other notices with NHTSA that list the 2015 Ford F-350 Super Duty. 21 of them deal with a problem owners have reported on this car. Newest first.
Federal rules make a manufacturer send NHTSA a copy of any notice about a defect that goes to more than one dealer or owner. Most of these are service bulletins, the repair instructions manufacturers send to dealers. NHTSA generally leaves safety recall bulletins out of this file, and recalls are listed separately.
Suspension noise, struts or alignment 2 bulletins · 65 complaints
Some 2005-2020 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions.
Some 2005-2019 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions.
Wheel bearing, tires or wheels 1 bulletin · 18 complaints
LINCOLN/FORD: ONCE PROCEDURE FOR HEATED STEERING WHEEL MODULE PROGRAM COMPLETED, HEATED STEERING WHEEL FAILS TO OPERATE PROPERLY AND PASSES NETWORK TEST BUT FAILS ON DEMAND SELF TEST.
Infotainment, screen or backup camera fails 3 bulletins · 15 complaints
Some 2015-2017 vehicles may experience a no crank concern due to a security access key table error. When attempting to program keys or perform a parameter reset, the procedure may fail and the Integrated Diagnostic System (IDS) scan tool may display an error ...
In some of the affected vehicles, the front control/display interface module (FCDIM) may have been unintentionally programmed for the European market instead of the North American market
1 more on this problem
FORD: CERTAIN TRUCKS WILL EXPERIENCE AN INOPERATIVE OR NON RESPONDING RADIO WHICH IS BEING INVESTIGATED REGARDING CAUSE AND IS NOT RECOMMENDING ATTEMPTING OR PERFORMING ANY REPAIRS OR REPLACEMENTS. MODEL 2016 F-SUPER DUTY. *PE
Check engine light or misfire 12 bulletins · 12 complaints
Some 2011-2016 F-Super Duty vehicles equipped with a 6.7L diesel engine may exhibit a lack of power and/or illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0299 in the powertrain control module (PCM).
Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM).
10 more on this problem
2015 F-Super Duty vehicles equipped with a 6.7L diesel engine may exhibit an illuminated MIL with DTCs P012F, P207F, P2002, and/or P20EE setting in the powertrain control module (PCM).
SOME 2015-2016 F-SUPER DUTY VEHICLES EQUIPPED WITH A 6.7L DIESEL ENGINE MAY EXHIBIT AN ILLUMINATED MIL WITH DTC P0170 (FUEL TRIM BANK 1) STORED IN THE POWERTRAIN CONTROL MODULE (PCM) MEMORY.
SOME 2011-2016 F-SUPER DUTY PICKUP VEHICLES BUILT ON OR BEFORE 23-FEB-2016 AND EQUIPPED WITH A 6.7L DIESEL ENGINE MAY EXHIBIT A RUNS ROUGH/MISFIRE CONDITION ONLY DURING THE EXHAUST REGENERATION PROCESS.
602L/6.8L Illuminated MIL with diagnostic trouble codes (DTCSF) P0627, P025B, P025A, and/or U019 - Built on or before 04/06/2016
6.7L DIESEL FUEL KNOCK AT IDLE WITH MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH MULTIPLE DIAGNOSTIC TROUBLE CODES (DTCS) ISSUE Some 2011-2016 F-Super Duty vehicles equipped with a 6.7L diesel engine may exhibit a fuel knock type noise at idle, illuminated MIL with ...
Torqshift Transmission - Malfunction indicator lamp (MIL) diagnostic trouble codes (DTCS) P0751, P0730 and/or P2700
FORD 2011-2016 F-SUPER DUTY: VARIOUS DIAGNOSTICS TROUBLE CODES; FUEL KNOCK NOISE AT IDLE WITH CONTRIBUTION OF CYLINDER *CN
FORD: WHEN SOME DIESEL TRUCKS ARE IDLING, WOULD EXPERIENCE A TYPE OF FUEL KNOCKING NOISE WITH ONE OR MORE CYLINDER CONTRIBUTION BALANCE. MODEL 2011-16 F-SUPER DUTY. *PE
FORD: VARIOUS 2013-2015 FORD F-SUPER DUTY VEHICLES EQUIPPED WITH 6.7L DIESEL ENGINES MIGHT EXPERIENCE AN CHECK ENGINE LIGHT MALFUNCTION WITH A NUMBER OF DIAGNOSTIC TROUBLE CODES. 7/15/15 *TA.
FORD: FUSE 33 NEED INSPECTING IN BATTERY JUNCTION BOX (BJB) FOR OPEN CONDITION IF TRUCKS EXHIBITING MALFUNCTION INDICATOR LAMP ILLUMINATION AND VARIOUS DTC WITH CRANK NO START OR ROUGH IDLE CONDITION. MODEL 2011-15 F SUPER DUTY. *PE
Engine failure, knocking or rod bearing 1 bulletin · 7 complaints
Some 2015-2019 F-Super Duty and 2016-2019 F-650/F-750 vehicles equipped with a 6.7L engine may exhibit an oil leak from the oil filter, crankcase vent oil separator, oil cooler, upper/lower oil pan.
Turbo failure or loss of boost 2 bulletins · 5 complaints
Some 2011-2021 vehicles equipped with a diesel engine may have engine oil in the exhaust after turbocharger replacement for various reasons.
SSM 47948 2010-2019 Various Vehicles - Turbocharged Engines - Oil Supply Filter Replacement When Replacing The Turbocharger Or The Turbocharger Oil Supply Tube For 2010-2019 vehicles equipped with turbocharged engines, when diagnosing and/or replacing turbo related ...
Complaints filed by year
37 complaints came in 2021, 1.9 times the year before. Owners file in waves when a problem gets press or an investigation, so a spike measures attention as much as failures.
NHTSA investigations
Sogefi secondary diesel fuel filter leak. Open.
NHTSA summary
Vehicle commanded engine shutdown. Closed mar 15, 2016, led to recall 15V-175.
NHTSA summary
Recalls that include the 2015 Ford F-350 Super Duty
Whether your car is included depends on its VIN. Check yours at nhtsa.gov/recalls.
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Risk and remedy
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.
Risk and remedy
Remedy: Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.
Ford Motor Company (Ford) is recalling certain model year 2011-2015 Ford F-350, F-450, and F-550 trucks manufactured February 22, 2010, to January 30, 2015, and equipped with ambulance or fire engine preparation packages. The affected vehicles may detect an incorrect Exhaust Gas Temperature Sensor (EGT) fault indicating that the vehicle is too hot, causing the engine management system to shut down the engine and prevent its immediate restart.
Risk and remedy
Remedy: Ford will notify owners, and dealers will update the Powertrain Control Module (PCM) software, free of charge. The recall began on April 22, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S09.
Ford Motor Company (Ford) is recalling certain model year 2015 F-250, F-350, F-450, and F-550 Super Duty trucks manufactured September 13, 2013, through March 28, 2014, and equipped with 6.2L gasoline or 6.7L diesel engines and 6R140 transmissions. An error with the transmission control software may be such that while shifting from "Park" to "Drive" the vehicle may display "Drive" but possibly engage "Reverse" for 1.5 seconds before engaging "Drive." Therefore, the vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."
Risk and remedy
Remedy: Ford will notify owners, and dealers will update the transmission software, free of charge. The recall began on May 6, 2014. Owners may contact Fords customer service at 1-800-392-3673. Ford's number for this recall is 14C04.
All 4 recalls on the 2015 Ford F-350 Super Duty, with the owner complaints on each recalled system
Guide NHTSA has an open investigation on this car. What the investigation stages mean
Questions
What is the most common problem on the 2015 Ford F-350 Super Duty?
Suspension, with 65 of the 207 complaints. Owners who gave a mileage for it put the median at about 82,000 miles.
At what mileage do 2015 Ford F-350 Super Duty problems start?
Of the 132 complaints that give a mileage, a quarter came by about 34,000 miles and half by about 61,000.
How many 2015 Ford F-350 Super Duty complaints involve a crash, fire or injury?
11 of them (5%). The typical vehicle on this site is at 6%.
Is there a recall for suspension on the 2015 Ford F-350 Super Duty?
No recall on file for the 2015 Ford F-350 Super Duty is on the same system as suspension. Another recall may still cover your car, so check its VIN at nhtsa.gov/recalls.