Battery dies or the car will not start

On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).Th

ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.

There is no summary currently available

There is no summary currently available

There is no summary currently available

SUMMARY: TOYOTA RECOVERED SOME FAILED IGNITION CONTROL MODULES FROM THEFIELD. INVESTIGATION SHOWED THAT A SOLDER JOINT IN THE POWER TRANSISTOROF THE MODULE WAS SUBJECT TO FAILURE. BECAUSE THE PART IS AN EMISSIONRELATED COMPONENT A VOLUNTARY EMISSIONS RECALL CAMPAIGN WAS CONDUCTED.THE PREDOMINANT MODE OF FAILURE IS AN INABILITY TO START THE ENGINE,ALTHOUGH A STALLED CONDITION CAN OCCUR WHILE THE ENGINE IS RUNNING.SINCE THE REPORTED OCCURENCE OF ACCIDENTS AND INJURIES IS SMALL, AND THEREPAIR IS BEING CONDUCTED UNDER THE EMISSIONS RECALL CAMPAIGN, THELIKLEHOOD OF FURTHER ACCIDENTS AND INJURIES IS REMOTE.===